中华医学超声杂志

应用化学 ›› 2010, Vol. 27 ›› Issue (10): 1182-1187.DOI: 10.3724/SP.J.1095.2010.90877

• 研究论文 • 上一篇    下一篇

NiO/WO3/TiO2-Al2O3催化剂上正庚烷的临氢异构化

汪颖军*,刘成双,罗洪君,李小辉   

  1. (大庆石油学院化学化工学院 大庆 163318)
  • 收稿日期:2009-12-25 修回日期:2010-03-31 出版日期:2010-10-10 发布日期:2010-10-10
  • 通讯作者: 汪颖军，男，博士，教授; E-mail:wangyingjun@163.com; 研究方向：工业催化
  • 基金资助:
    黑龙江省科技攻关计划项目(GZ06A-401)

Catalysis of NiO/WO3/TiO2-Al2O3 on n-Heptane Hydroisomerization

WANG Ying-Jun*, LIU Cheng-Shuang, LUO Hong-Jun, LI Xiao-Hui   

  1. (College of Chemistry and Chemical Engineering,Daqing Petroleum Institute,Daqing 163318)
  • Received:2009-12-25 Revised:2010-03-31 Published:2010-10-10 Online:2010-10-10

PDF

1298

摘要：

采用溶胶凝胶法制备了TiO2-Al2O3复合载体，用分步浸渍法制备了NiO/WO3/TiO2-Al2O3催化剂。 在常压连续流动固定床反应器上考察了NiO/WO3/TiO2-Al2O3对正庚烷临氢异构化反应的催化性能。 研究了催化剂中WO3含量、Ni含量、焙烧温度和还原温度及催化反应温度对临氢异构化反应的影响。 采用XRD和BET方法对催化剂进行了表征。 结果表明，当w(WO3)=25%、w(Ni)=10%时，所制备的NiO/WO3/TiO2-Al2O3催化剂对正庚烷异构化反应的催化性能最好，活性可达15.50%，选择性可达84.06%。

关键词: NiO/WO3/TiO2-Al2O3, 催化剂, 正庚烷, 临氢异构化

Abstract:

TiO2-Al2O3 catalyst support was prepared by the sol-gel method and NiO/WO3/TiO2-Al2O3 catalyst was prepared by stepwise impregnation. Hydroisomerization of n-heptane over the NiO/WO3/TiO2-Al2O3 catalyst was investigated in a continuous flow fixed-bed reactor under atmospheric pressure. The catalysts were characterized using XRD and BET surface area. The effects of WO3 content, Ni content, calcination temperature, reduction temperature, reaction temperature on the catalytic performance were studied systematically. The result showed that when the mass fraction of WO3 and Ni in the catalyst was 25% and 10%, respectively, the highest catalytic activity of NiO/WO3/TiO2-Al2O3 could be achieved. The conversion of n-heptane is 15.50% while the isomerization selectivity of i-heptane can reach 84.06%.

Key words: NiO/WO3/TiO2-Al2O3, catalyst, n-heptane, hydroisomerization

中图分类号: 

网站版权 © 应用化学     本网站备案：吉ICP备12000082号