亚铁离子对驱油聚合物溶液黏度的影响及其降黏机理

doi:10.3724/SP.J.1095.2013.30169

摘要/Abstract

摘要： 采用NaOH沉淀法去除胜坨油田T28区污水含有的亚铁离子(Fe2+)，使配制的聚合物溶液黏度增加，通过红外光谱仪(IR)、荧光光谱仪及扫描电子显微镜(SEM)对Fe2+的降黏机理进行了分析。结果表明，采用NaOH沉淀法处理Fe2+含量为5.9 mg/L的污水，控制pH=9，聚合物溶液的黏度可由19.17 mPa·s提高到92.50 mPa·s。 Fe2+使聚合物大分子发生断链，分子间的缔合作用减弱，破坏了分子链间形成的空间网络结构，导致溶液黏度显著降低；当用NaOH处理Fe2+后形成了Fe(OH)2沉淀而析出，同时使聚合物分子链间形成致密的空间网络结构。

关键词: 聚合物, 亚铁离子, 黏度, 机理

Abstract: The viscosity of prepared polymer solution was increased by the precipitation of Fe2+ with NaOH from the sewage of the T28 district, Shengtuo oilfiled.The mechanism of reduced viscosity introduced by Fe2+ was studied by IR, fluorescence spectroscopy and SEM. The viscosity of polymer solution was elevated from 19.17 mPa·s to 92.50 mPa·s when treating the sewage containing 5.9 mg/L of Fe2+ with NaOH at pH 9. Fe2+ was found to split the polymer chain, weaken the association, destroy the spatial network structure of macromolecules, and lead to decreasing viscosity of the polymer solution. The precipitation of ferrous hydroxides from the polymer solution promotes the formation of compact spatial network structure of the polymer chains.

Key words: polymer, ferrous ion, viscosity, mechanism

中图分类号:

O631.1

黄漫, 李美蓉, 田兰兰, 黄银, 马宝东, 刘坤. 亚铁离子对驱油聚合物溶液黏度的影响及其降黏机理[J]. 应用化学, DOI: 10.3724/SP.J.1095.2013.30169.

HUANG Man1, LI Meirong1*, TIAN lanlan1, HUANG Yin1, MA Baodong2, LIU Kun2. Effect of Ferrous Ion on Reducing the Viscosity of Oil Flooding Polymer Solution and Its Mechanism[J]. Chinese Journal of Applied Chemistry, DOI: 10.3724/SP.J.1095.2013.30169.

参考文献

[1] Shi L T,Chen L,Ye Z B,et al. Effect of Polymer Solution Structure on Displacement Efficiency[J]. Pet Sci,2012.(9):230-235.

[2] WANG Baojiang,LIU Guangshun. A Study on the Polymer Solution Preparing with Fresh Water and Diluting with Produced Water[D]. Daqing:Daqing Petroluem Institute,2003(in Chinese).

王宝江,刘广舜. 清水配制污水稀释聚合物溶液试验研究[D]. 大庆:大庆石油学院,2003.

[3] FAN Hanxiang,HUANG Feng,DONG Zehua,et al. Influence on the Viscosity of HPAM Solution for Iron[J]. Sichuan Chem Corros Control,1999,2(3):12-14(in Chinese).

范汉香,黄峰,董泽华,等. 铁离子对HPAM溶液黏度的影响[J]. 四川化工与腐蚀控制,1999,2(3):12-14.

[4] WANG Zhen,ZHENG Jingtang. Influencing Factors and Mechanism Discussed on the Viscosity of Polymer Solution Prepared by Oilfield Produced Water[D]. Qingdao:China University of Petroleum(East China),2009:21-28(in Chinese).

王振,郑经堂. 污水配制聚合物溶液黏度的影响因素及其机理探讨[D]. 青岛:中国石油大学（华东）,2009:21-28.

[5] LI Meirong,LIU Zhi,SONG Xinwang,et al. Effect of Metal Ions on the Viscosity of Polyacrylamide Solution and the Mechanism of Viscosity Degradation[J]. J Fuel Chem Technol,2012,40(1):44-47(in Chinese).

李美蓉,柳智,宋新旺,等. 金属阳离子对聚丙烯酰胺溶液黏度的影响及其降黏机理研究[J]. 燃料化学学报,2012,40(1):44-47.

[6] LIU Qiong,WU Wenhui,CHEN Ying,et al. Fluorescence Probe Study on Associative Behaviors of Hydrophobically Modified Polyacrylamide in Aqueous Solution[J]. J Funct Polym,2005,18(1):23-27(in Chinese).

刘琼,吴文辉,陈颖,等. 荧光探针法研究疏水改性聚丙烯酰胺溶液的疏水缔合行为[J]. 功能高分子学报,2005,18(1):23-27.

[7] JIANG Liufeng,ZHONG Chuanrong,XU Min,et al. Solution Properties and Microstructure of Branched Acrylamide-Based Copolymers[J]. Acta Phys Chem Sin,2010,26(3):535-540(in Chinese).

蒋留峰,钟传蓉,徐敏,等. 接枝丙烯酰胺共聚物的溶液性能和微结构[J]. 物理化学学报,2010,26(3):535-540.

[8] HUANG Junli. A New Type of Water Treatment Agent of Chlorine Dioxide Technology and Its Application[M]. Beijing:Chemical Industry Press,2003:44-45(in Chinese).

黄君礼. 新型水处理剂二氧化氯技术及其应用[M]. 北京:化学工业出版社,2003:44-45.

[9] MENG Lingwei,KANG Wanli,LIU Liping,et al. Effect of Sulfide Ion on Viscosity of HPAM Solution and Sulfide Removal[J]. Oilfield Chem,2009,26(3):294-295(in Chinese).

孟令伟,康万利,刘莉萍,等. 硫离子对HPAM溶液黏度的影响及除硫方法研究[J]. 油田化学,2009,26(3):294-295.

[10] SUN Lin,PU Wanfen,XIN Jun. Study on Viscosity-affecting Factors for Alkali/Polymer Flooding System[J]. Adv Fine Petrochem,2007,8(4):11-16(in Chinese).

孙琳,蒲万芬,辛军. 碱/聚合物复合驱体系黏度影响因素分析[J]. 精细石油化工进展,2007,8(4):11-16.

[11] Bromberg L E,Barr D P. Aggregation Phenomena in Aqueous Solutions of Hydrophobically Modified Polyelectrolytes:a Probe Solubilization Study[J]. Macromolecules,1999,32(11):3649-3657.

[12] GAN Mengyu,LI Xiaomei,MA Li,et al. Studies on Polymerization Behavior of Organosilicoacry Latex with Core-shell Structure Using Fluorescence Probe Technique[J]. Acta Polym Sin,2010,(3):268-273(in Chinese).

甘孟瑜,李小梅,马利,等. 荧光探针法研究核壳结构有机硅-丙烯酸酯乳液的聚合行为[J]. 高分子学报,2010,(3):268-273.

[13] JIANG Guiyuan,REN Kun,XU Chunming,et al. Solution and Characterization of Hydrophobically Associating Water-soluble Polymers[J]. J Univ Pet(Nat Sci Edn),2005,29(2):118-120(in Chinese).

姜桂元,任鲲 ,徐春明,等. 疏水缔合水溶性聚合物的合成及表征[J]. 石油大学学报(自然科学版),2005,29(2):118-120.

[1]	陈兵帅, 卓海涛, 黄书, 陈少军. 高性能硅基负极聚合物粘结剂的研究进展[J]. 应用化学, 2023, 40(5): 625-639.
[2]	雷学博, 刘慧景, 丁赫宇, 申国栋, 孙润军. 用于降解印染废水中有机污染物的光催化剂的研究进展[J]. 应用化学, 2023, 40(5): 681-696.
[3]	兰晓琳, 郑红星, 张依帆, 赵振, 肖和业, 王志江, 邓鹏飏. 常压高温固相反应制备SiC陶瓷粉体的研究进展[J]. 应用化学, 2023, 40(4): 476-485.
[4]	陶雨晨, 候晓慧, 尹登科, 杨晔. 基于电场调控的胆固醇基液晶薄膜对成纤维细胞生长分化的影响[J]. 应用化学, 2023, 40(4): 546-553.
[5]	许祥民, 邓杰, 杜雨琪, 沈红亮, 安泽坤, 孙才英. 螺环磷酰咪唑阻燃棉织物的热解挥发物分析及热解机理推测[J]. 应用化学, 2023, 40(3): 380-388.
[6]	刘进剑, 陆艺炜. 羧苄基紫精配位聚合物的多重响应行为[J]. 应用化学, 2023, 40(3): 397-403.
[7]	王华宇, 张超, 陈柯铭, 葛明. 金属-有机框架MIL-88A（Fe）及其复合材料在水处理中的研究进展[J]. 应用化学, 2023, 40(2): 155-168.
[8]	张琴, 刘文彬, 樊利娇, 谢宇铭, 黄国林. 功能化介孔二氧化硅的制备及其吸附分离水中铀的研究进展[J]. 应用化学, 2023, 40(2): 169-187.
[9]	刘进剑, 刘娜, 杨凤意. 2种同构紫精配位聚合物的合成及其光致变色性能[J]. 应用化学, 2023, 40(2): 245-251.
[10]	李玉凰, 卢泽毅, 袁红梅, 王刚, 张成江. 酰腙键聚合物凝胶的制备及其在硝基呋喃类药物分析中的应用[J]. 应用化学, 2023, 40(1): 100-108.
[11]	姚競, 戴明明. 基于乘用车轮胎胎面胶粉的再生橡胶的制备及性能[J]. 应用化学, 2023, 40(1): 52-58.
[12]	解冠宇, 李茂. 拓扑结构不同金属有机聚合物的电化学聚合行为和光谱电化学性质[J]. 应用化学, 2022, 39(8): 1246-1251.
[13]	李自力, 徐兴冉, 湛江浩, 胡晓华, 张子英, 熊诗圣. 先进光刻材料[J]. 应用化学, 2022, 39(6): 859-870.
[14]	宋林虎, 李世友, 王洁, 张晶晶, 张宁霜, 赵冬妮, 徐菲. 锂离子电池电解液除酸除水添加剂的研究进展[J]. 应用化学, 2022, 39(5): 697-706.
[15]	王雪, 王意波, 王显, 祝建兵, 葛君杰, 刘长鹏, 邢巍. 酸性电解水过程中氧析出反应的机理及铱基催化剂的研究进展[J]. 应用化学, 2022, 39(4): 616-628.