γ-AlOOH纳米棒的水热合成与形貌调控

doi:10.11944/j.issn.1000-0518.2018.08.180129

摘要/Abstract

摘要：

γ-AlOOH作为液相法合成γ-Al₂O₃的前驱体,其形貌与最终产物的性能密切相关。本文采用水热法合成γ-AlOOH纳米棒,通过改变Al³⁺浓度和沉淀剂的种类调控γ-AlOOH纳米棒的长径比,利用X射线衍射仪(XRD)和透射电子显微镜(TEM)表征产物的晶体结构和形貌。结果表明,随Al³⁺浓度增大可得到长径比在5.9~8.0的γ-AlOOH纳米棒,而改变沉淀剂的种类可进一步将长径比增大到8.0~10.0。通过对产物结晶过程的分析,发现增大Al³⁺浓度和增强沉淀剂碱性均可以促进铝离子与羟基的配合。提高反应体系中Al(OH)₃浓度,有利于γ-AlOOH晶粒的成核,促进了晶核之间的定向接触,从而提高了纳米棒的长径比。长径比为10.0的γ-AlOOH纳米棒烧结所得纳米γ-Al₂O₃改性变压器油(体积分数为0.1%)的正冲击击穿强度较纯油提高9.9%.

关键词: γ-AlOOH;, 纳米棒, Al³⁺, 沉淀剂种类, 定向接触

Abstract:

The morphology of γ-AlOOH, as a precursor to γ-Al₂O₃ in the liquid-phase synthesis system, is closely related with the performance of final product. In this paper, γ-AlOOH nanorods were synthesized by hydrothermal method. The aspect ratio of γ-AlOOH nanorods was modified by changing the concentration of Al³⁺ and the type of base. The crystal structure and morphology of the as-synthesized products were characterized by X-ray diffraction(XRD) and transmission electron microscopy(TEM). The results show that the aspect ratio of γ-AlOOH nanorods can be tuned in the range of 5.9~8.0 with the increase of concentration of Al³⁺, and further adjusted into 8.0~10.0 by changing the type of base. Based on the analysis of the crystallization process, it is believed that the complexation reaction between aluminum ions and hydroxyl groups is accelerated by increasing the concentration of Al³⁺ and the base strength of precipitants. The increase of the content of Al(OH)₃ is beneficial to the formation of γ-AlOOH nuclei and facilitates the oriented attachment of nuclei, leading to a significant increase of aspect ratio of nanorods. The positive impact breakdown strength of transformer oil modified by nano γ-Al₂O₃(volume fraction of 0.1%) obtained by sintering γ-AlOOH nanorods with a length to diameter ratio of 10.0 is 9.9% higher than that of pure oil.

Key words: γ-AlOOH;, nanorod, Al³⁺, type of precipitate, oriented attachment

吕玉珍, 孙倩, 韩秋波, 孙振, 黄猛, 李成榕. γ-AlOOH纳米棒的水热合成与形貌调控[J]. 应用化学, 2018, 35(8): 932-938.

LÜ Yuzhen, SUN Qian, HAN Qiubo, SUN Zhen, HUANG Meng, LI Chengrong. Hydrothermal Synthesis and Morphological Control of γ-AlOOH Nanorods[J]. Chinese Journal of Applied Chemistry, 2018, 35(8): 932-938.

参考文献

[1]	SIMA Wenxia,CAO Xuefei,YANG Qing,et al. Comparison and Analysis of Breakdown Properties of Three Kinds of Nano-Modified Transformer Oil Under Impact Voltage[J]. High Voltage Technol,2015,41(2):374-381(in Chinese). 司马文霞,曹雪菲,杨庆,等. 冲击电压下3种纳米改性变压器油击穿特性的比较和分析[J]. 高电压技术,2015,41(2):374-381.
[2]	Yang Q,Liu M,Sima W X,et al. Effect of Electrode Materials on the Space Charge Distribution of an Al2O3 Nano-Modified Transformer Oil Under Impulse Voltage Conditions[J]. J Phys D Appl Phys,2017,50(46):1-10.
[3]	Singh M,Kundan L.Experimental Study on Thermal Conductivity and Viscosity of Al2O3-Nanotransformer Oil[J]. Int J Theor Appl Res Mech Eng,2013,2(3):108-112.
[4]	ZHANG Yonggang,YAN Pei.Preparation and Application of Nano-alumina[J]. Inorg Salt Ind,2001,33(3):19-22(in Chinese). 张永刚,闫裴. 纳米氧化铝的制备及应用[J]. 无机盐工业,2001,33(3):19-22.
[5]	LI Jinlin,ZHANG Xin,WANG Li,et al. Controllable Synthesis and Characterization of γ-Al2O3 Nanocrystals with Specific Morphology[J]. J South China Univ Nat(Nat Sci Ed),2016,35(4):1-4(in Chinese). 李金林,张鑫,王立,等. 特定形貌γ-Al2O3纳米晶的可控合成及其表征[J]. 中南民族大学学报:自然科学版,2016,35(4):1-4.
[6]	JING Xiaoyan,YU Xueqing,ZHANG Milin.Preparation of Nano γ-Al2O3[J]. Appl Sci Technol,2004,31(9):56-58(in Chinese). 景晓燕,于学清,张密林. 纳米γ-Al2O3的制备研究[J]. 应用科技,2004,31(9):56-58.
[7]	Yi J H,Sun Y Y,Gao J F,et al. Synthesis of Crystalline γ-Al2O3 with High Purity[J]. Trans Nonferrous Met Soc China,2009,19(5):1237-1242.
[8]	Abdollahifar M.Synthesis and Characterisation of γ-Al2O3 with Porous Structure and Nanorod Morphology[J]. J Chem Res,2014,38(3):154-158.
[9]	Bell T E,Gonzalezcarballo J M,Tooze R P,et al. Single-Step Synthesis of Nanostructured g-Alumina with Solvent Reusability to Maximise Yield and Morphological Purity[J]. J Mater Chem A,2015,3(11):6196-6201.
[10]	Jiang Z Q,Ma H W,Yang J,et al. Synthesis of Nanosized Pseudoboehmite and γ-Al2O3 by Control Precipitation Method[J]. Adv Mater Res,2013,684:46-52.
[11]	JIANG Qingmin,ZHI Hongmei,YANG Mei,et al. Preparation and Application of Nanometer Alumina[J]. Diamond Abrasiv Eng,2014,34(3):77-82(in Chinese). 蒋清民,智红梅,杨梅,等. 纳米氧化铝的制备及应用进展[J]. 金刚石与磨料磨具工程,2014,34(3):77-82.
[12]	LI Yan,SONG Meihui.Preparation and Modification of Nano-Alumina[J]. Heilongjiang Sci,2012,(2):38-41(in Chinese). 李岩,宋美慧. 纳米氧化铝的制备及其改性研究[J]. 黑龙江科学,2012,(2):38-41.
[13]	Xiang Y C,Soon W Lee. pH-Dependent formation of Boehmite (γ-AlOOH) Nanorods and Nanoflakes[J]. Chem Phys Lett,2007,438(4):279-284.
[14]	Bell T E,Gonzálezcarballo J M,Tooze R P,et al. γ-Al2O3 Nanorods with Tuneable Dimensions—A Mechanistic Understanding of Their Hydrothermal Synthesis[J]. RSC Adv,2017,7(36):22369-22377.
[15]	Yang Q.The Reaction Conditions Influence on Hydrothermal Synthesis of Boehmite Nanorods[J]. Inorg Mater,2010,46(9):953-958.
[16]	Li Y Y,Liu J P,Jia Z J.Fabrication of Boehmite AlOOH Nanofibers by a Simple Hydrothermal Process[J]. Mater Lett,2006,60(29):3586-3590.
[17]	Wang X,Wang Z D.Particle Effect on Breakdown Voltage of Mineral and Ester Based Transformer Oils[C]. Electrical Insulation and Dielectric Phenomena,Quebec City,Canada,2008:598-602.
[18]	Chen X Y,Zhang Z J,Li X L,et al. Controlled Hydrothermal Synthesis of Colloidal Boehmite(γ-AlOOH) Nanorods and Nanoflakes and Their Conversion into γ-Al2O3, Nanocrystals[J]. Solid State Commun,2008,145(7):368-373.
[19]	LI Youzhu,HUANG Zhaoming,WANG Shengzhang,et al. Hydrothermal Synthesis and Thermal Decomposition of Alumina Nanorods[J]. J Inorg Mater,2008,23(1):121-124(in Chinese). 李友竹,黄昭铭,王圣璋,等. 水热合成与热分解法制备氧化铝纳米棒[J]. 无机材料学报,2008,23(1):121-124
[20]	LU Guangwei,YANG Qi,Deng Yida,et al. Hydrothermal Synthesis of One-Dimensional Nanostructured γ-AlOOH Nanostructures[J].J Inorg Mater,2009,24(3):463-468(in Chinese). 陆光伟,杨琪,邓意达,等. 水热法制备一维纳米γ-AlOOH的形态结构[J]. 无机材料学报,2009,24(3):463-468.
[21]	Hwang J G,Zahn M,Osullivan F M,et al. Effects of Nanoparticle Charging on Streamer Development in Transformer Oil-Based Nanofluids[J]. J Appl Phys,2010,107(1):014310.