苄基淀粉醚与烷基多糖苷复配制备氰氟草酯水乳剂

doi:10.3724/SP.J.1095.2013.20535

摘要/Abstract

摘要： 以苄基淀粉醚与烷基多糖苷复配为乳化剂，油酸甲酯为溶剂，采用浓缩乳化法制备了高度稳定的10%氰氟草酯水乳剂。分析了苄基淀粉醚的红外和紫外特征图谱。采用正交试验设计，通过测定乳滴粒径分布，结合乳液外观，研究了乳化方法、预处理液中苄基淀粉醚与烷基多糖苷质量分数、转速和剪切时间等工艺条件对乳液稳定性的影响。结果表明，苄基淀粉醚与原淀粉相比，在红外、紫外光照射下出现了苯甲基的特征吸收峰。以苄基淀粉醚与烷基多糖苷质量比3∶2复配为乳化剂、质量分数9%油酸甲酯为溶剂制备的10%氰氟草酯水乳剂，乳滴平均粒径在1.02 μm左右，且经(54±2) ℃密封14 d加速试验和常温储存6个月后，平均粒径仅增长0.1~0.6 μm，析水率为2.7%，均优于用常规乳化剂和溶剂制备的10%氰氟草酯水乳剂。因此，苄基淀粉醚与烷基多糖苷以及油酸甲酯可作为备选乳化剂和溶剂，用于环境相容性好的农药剂型加工。

关键词: 氰氟草酯, 水乳剂, 苄基淀粉醚, 烷基多糖苷, 油酸甲酯

Abstract: To replace the common emulsifiers and solvents, the mix-emulsifier of benzyl starch ether in combination with alkyl polyglycoside and solvent of methyl oleate were used in preparation of 10% cyhalofop-butyl aqueous emulsions. The structure of benzyl starch ether was characterized by FTIR and UV spectroscopies in case of benzyl carboxymethy. The effects of different processing parameters, including the concentration of benzyl starch ether and alkyl polyglycoside in pretreatment fluid, rotation speed and shearing time on the stability of emulsion were studied by measuring oil droplet diameter distribution and using the orthogonal experimental design. The results demonstrate that benzyl starch ether compared with pristine starch has absorption peak of benzyl carboxymethyl. High stable emulsions can be prepared with benzyl starch ether and alkyl polyglycoside complex in 3∶2 molar ratio as emulsifier and 9% methyl oleate as solvent. The mean droplet diameter of emulsions is about 1.02 μm and is increased by only 0.1~0.6 μm after storing at 25 ℃ for 6 months or at (54±2) ℃ for 14 days and the water separating proportion is only 2.7%. Cyhalofop-butyl oil-in-water emulsion prepared with benzyl starch ether, alkyl polyglycoside and methyl oleate has a better stability than the conventional emulsions. The results of this study show that benzyl starch compounding with alkyl polyglycosid and methyl oleate can be used as an alternative emulsifier and solvent for the environmentally friendly oil-in-water emulsion formulations.

Key words: cyhalofop-butyl, emulsion in water, benzyl starch, alkyl polyglycosid, methyl oleate

中图分类号:

O648

商建, 杨凯凯, 刘峰. 苄基淀粉醚与烷基多糖苷复配制备氰氟草酯水乳剂[J]. 应用化学, DOI: 10.3724/SP.J.1095.2013.20535.

SHANG Jian, YANG Kaikai, LIU Feng*. Application of Benzyl Starch and Alkyl Polysaccharide Glycoside as Mix-emulsifier in Preparation of Aqueous Cyhalofop-butyl Emulsion[J]. Chinese Journal of Applied Chemistry, DOI: 10.3724/SP.J.1095.2013.20535.

参考文献

[1] Shi Y L,Zheng T,Shang Q. Preparation of Acrylic/Acrylate Copolymeric Surfactants by Emulsion Polymerization Used in Pesticide Oil-in-Water Emulsions[J]. J Appl Polym Sci,2012,123:3117-3127.

[2] Farhadian M,Vachelard C,Duchez D,et al. In Situ Bioremediation of Monoaromatic Pollutants in Ground Water[J]. Bioresour Technol,2008,99(13):5296-5308.

[3] Falconer Ian R. Are Endocrine Disrupting Compounds a Health Risk in Drinking Water[J]. Public Health,2006,3(2):180-184.

[4] Staples C A,Weeks J,Hall J F,et al. Evaluation of Aquatic Toxicity and Bioaccumulation of C8 and C9 Alkyl Phenol Ethoxylates[J]. Environ Toxicol Chem,1998,17(2):2470-2480.

[5] Ruiz-santaella J R,Heredia A,Prado R. Basis of Selective of Cyhalofop-butyl in Oryza Sativa L[J]. Planta,2006,223:191-199.

[6] Shibayama H. Weeds and Weed Management in Rice Production in Japan[J]. Weed Biol Manage,2001,(1):53-60.

[7] Pinna M V,Pusino A. Direct and Indirect Photolysis of Cyhalofop in Aqueous Systems[J]. Chemosphere,2011,(82):817-821.

[8] WU Changxing,ZHAO Xueping,WU Shenggan,et al. Toxicity and Risk of Herbicide Cyhalofop-butyl on Rana limnocharis[J]. Acta Agric Zhejiangensis,2011,23(4):771-775(in Chinese).

吴长兴，赵学平，吴声敢，等. 氰氟草酯对泽蛙蝌蚪毒性及风险[J]. 浙江农业学报,2011,23(4):771-775.

[9] LU Mei,WANG Jinxin,LIAN Yuzhu,et al. Synergism of Methyl Oleate Adjuvant Herbicides and Its Safety on Soybean at Seeding[J]. J Shandong Agric Univ(Nat Sci Edn),2006,37(1):31-34(in Chinese).

鲁梅,王金信,连玉朱,等. 油酸甲酯助剂对除草剂增效作用及其对大豆苗期安全性测定[J]. 山农农业大学学报（自然科学版）,2006,37(1):31-34.

[10] Abribat B,Ponthierry S B,Lachut F,et al. Microemulsions as Adjuvants for Agricultural Chemicals:US,8138120B2[P],2009-07-12.

[11] ZHANG Yuan,SHANG Jian,ZHANG Xiaobing,et al. Stability Mechanism of Lambda-Cyhalothrin O/W Emulsion Prepared with Esterified Starch as Emulsifer[J]. Chinese J Appl Chem,2012,29(3):332-339(in Chinese).

张源,商建,张小兵,等. 酯化淀粉乳化剂制备的高效氯氟氰菊酯O/W乳液的稳定机制[J]. 应用化学,2012,29(3):332-339.

[12] Cho K Y,Lim S T. Preparation and Properties of Benzyl Corn Starches[J]. Starch,1998,50(6):250-257.

[13] BeMiler J N,Lafayette W. Starch Modification:Challenges and Prospects[J]. Starch,1997,49(4):127-131.

[14] WANG Cai,PAN Zelin,ZHAO Ping,et al. Amphiphilic Starch Derivative Fine Particle and Its Preparation Method:CN,200610169763.4[P],2008-07-02(in Chinese).

王才,潘则林,赵萍,等. 双亲性淀粉衍生物微细颗粒及其制备方法:中国,200610169763.4[P],2008-07-02.

[15] LU Bin，WU Wei. Optimization of Preparation of Dexamethasone Acetate-Loaded Poly(D,L-lactide) Microspheres by Central Composite Design[J]. Acta Pharm Sin,1999,34(5):387-391(in Chinese).

陆彬,吴伟. 中心多点等距设计法优化醋酸地塞米松聚丙交酯微球的制备工艺[J]. 药学学报,1999,34(5):387-391.

[16] GUO Wuli. Liquid Formulation[M]. Beijing:Chemical Industry Press,2003:90-100( in Chinese).

郭武棣. 液体制剂[M]. 北京:化学工业出版社,2003:90-100.

[17] ZHANG Yanping. The Manufacture and Application of Modified Starch[M]. Beijing:Chemical Industry Press,2007:190-200(in Chinese).

张燕萍. 变性淀粉的制造与应用[M]. 北京：化学工业出版社,2007:190-200.

[18] Heinze T,Rensing S,Koschella A. Starch Derivatives of High Degree of Functionalization:13.Novel Amphiphilic Starch Products[J]. Starch,2007,59:199-207.

[19] XIA Tingting,TANG Yanfeng,DING Yinyu. A New UV-Spectrophotometric Method for the Determination of Substitution Degree of Benzyl Starch[J]. J Nantong Univ(Nat Sci Edn),2010,9(4):36-38(in Chinese).

夏婷婷,汤艳峰,丁欣宇. 紫外分光光度法测定苄基淀粉苄基取代度的新方法[J]. 南通大学学报（自然科学版）,2010,9(4):36-38.

[20] Bohrisch J,Vorwerg W,Radosta S. Development of Hydrophobic Starch[J]. Starch,2004,56(7):322-329.

[21] ZHANG Hongguang,DONG Shouping,JIANG Xuemei. Mechanism of Deformation and Breakup of Single Drop in a Shear or an Extensional Flow[J]. Sci Technol Eng,2006,6(24):3896-3899(in Chinese).

张红光,董守平,姜雪梅. 剪切或拉伸流场中油滴的变形和破裂准则[J]. 科学技术与工程,2006,6(24):3896-3899.

[22] Sajjadi S. Formation of Fine Emulsions by Emulsification at High Viscosity or Low Interfacial Tension:A Comparative Study[J]. Colloid Interface Sci A,2007,299:73-78.

[23] XUE Shiying. Microcapsule Technology:Principle and Application[M]. Beijing:Chemical Industry Press,2006:30-45(in Chinese).

许时婴. 微胶囊技术:原理及应用[M]. 北京：化学工业出版社,2006:30-45.