Preparation of Nickel Oxide-Zinc Ferrite Composite Thin Film/Tin-diffused Glass Optical Waveguide Sensor and Its Gas-sensing for Hydrogen Sulfide

doi:10.3724/SP.J.1095.2014.30256

Chinese Journal of Applied Chemistry

• Full Papers • Previous Articles Next Articles

Preparation of Nickel Oxide-Zinc Ferrite Composite Thin Film/Tin-diffused Glass Optical Waveguide Sensor and Its Gas-sensing for Hydrogen Sulfide

MADINA¹, MUZAPAR Mamtimin², AMANGUL Turhun¹, Erkin Tursun¹, ABLIZ Yimit^1*

(1.College of Chemistry and Chemical Engineering,Xinjiang University,Urumqi 830046,China；
2.College of Information,Beijing University of Chemical Technology,Beijing 102200,China)

Received:2013-05-20 Revised:2013-07-21 Published:2014-03-10 Online:2014-03-10
Contact: Abliz

Abstract

Abstract: NiO doped ZnFe2O4 sol synthesized by a sol-gel method was dip-coated on a tin-doped glass optical waveguide to fabricate a sensor used for the detection of poisonous gases. The results show that the as-prepared composite film has a good selectivity toward H2S over other gases with the same concentration. The detection limit of H2S is 1.0×10-9(volume ratio) and the corresponding response and recovery time are 6 s and 8 s, respectively. The advantages of sensor encompass easy fabrication, room temperature operation, high sensitivity, fast response and recovery speed, good reversibility and repeatability.

Key words: optical waveguide gas sensor, nickel oxide-zinc ferrite composite film, hydrogen sulfide gas

CLC Number:

null

MADINA1, MUZAPAR Mamtimin2, AMANGUL Turhun1, Erkin Tursun1, ABLIZ Yimit1*. Preparation of Nickel Oxide-Zinc Ferrite Composite Thin Film/Tin-diffused Glass Optical Waveguide Sensor and Its Gas-sensing for Hydrogen Sulfide[J]. Chinese Journal of Applied Chemistry, DOI: 10.3724/SP.J.1095.2014.30256.

References

[1] LIU Xiaoqun,JIANG Hongfu,YAO Wenrui. Devlopment Study on Removing Hydrogen Sulfide[J]. Anhui Chem Ind,2004,(5)：33-37(in Chinese).

刘小群,江宏富,姚文锐. 硫化氢脱除技术研究进展[J]. 安徽化工,2004,（5）：33-37.

[2] JIANG Ming,NING Ping,SHI Yan. Determination of Hydrogen Sulfide in Waste Sas by Gas Chromatography[J]. Environ Health,2008,25(12):1088-1089(in Chinese).

蒋明，宁平，师雁. 废气中硫化氢的气相色谱测定法[J]. 环境与健康杂志,2008,25(12):1088-1089.

[3] JIN Micong,FU Zhanming,YAN Jinliang,et al. Determination of Hydrogen Sulfide in Air by Ultraviolet Spectroscopy[J]. Chinese J Prev Med,2000,34(1):50-51(in Chinese).

金米聪，符展明，颜金良,等. 紫外分光光度法测定空气中硫化氢[J]. 中华预防医学杂志,2000,34(1):50-51.

[4] WANG Xiaobing,KOU Yupeng,LIANG Huijun,et al. Study on the Gas-sensing Properties of CuO-doped Nanometer SnO2[J]. Electron Compon Mater,2008,27(2):16-18(in Chinese).

王晓兵，寇玉鹏，梁慧君,等. CuO掺杂纳米SnO2的气敏性能研究[J]. 电子元件与材料,2008,27(2):16-18.

[5] Wang C H,Chu X F,Wu M M. Detection of H2S Down to ppb Levels at Room Temperature Using Sensors Based on ZnO Nanorods[J]. Sens Actuators B,2006,113(1):320-323.

[6] Hayrensa A,Abliz Y,Mamtimin M,et al. Nation Film/K-exchanged Glass Optical Waveguide Sensor for BTX Detection[J]. Anal Chem,2008,80(20):7678-7683.

[7] Razak K,Abliz Y,Hayrensa A,et al. Optical Waveguide BTX Gas Sensor Based on Polyacrylate Resin Thin Film[J]. Environ Sci Technol,2009,43(13):5113-5116.

[8] Abliz Yimit,Dilnur Talif,Arkin Tursun,et al. The Application of Highly Sensitive Composite Optical Waveguide in the Ozone Detection[J]. Chinese J Anal Chem,2005,33(11):1663-1665(in Chinese).

阿布力孜·伊米提，迪丽努尔·塔力甫，艾尔肯·吐尔逊,等. 高灵敏复合光波导在检测臭氧的应用研究［J］. 分析化学,2005，33(11):1663-1665.

[9] Abdukadir Abdikiyum,Abliz Yimit. Detection of H2S Gas by Optical Waveguide Sensor Based on Thionine Doped Polyvinyl Alcohol Film[J]. Chinese J Appl Chem,2010,27(8):960-964(in Chinese).

阿不都卡德尔·阿不都克尤木,阿布力孜·伊米提. 基于硫堇掺杂的聚乙烯醇薄膜的光波导传感器检测硫化氢气体[J]. 应用化学,2010,27(8):960-964.

[10] Ranagul Abdurahman,Abliz Yimit. Application of Optical Waveguide in the Acidic Gases Detection[J]. Chem Res Appl,2012,24(3):295-399(in Chinese).

热娜古丽·阿不都热合曼,阿布力孜·伊米提. 光波导传感元件在检测酸性气体中的应用[J]. 化学研究与应用,2012,24(3):295-399.

[11] Buso D,Guglielmi M,MartucciA,et al. Growth of Cookie-like Au/NiO Nanoparticles in SiO2 Sol-gel Films and Their Optical Gas Sensing Properties[J]. Cryst Growth Des,2008,8(2):744-749.

[12] Mohammed S A,Atel A A,kamal H. Opto-structural, Electrical and Electrochromic Properties of Crystalline Nickel Oxide Thin Films Prepared by Spray Pyrolysis[J]. Phys B,2002,311(3/4):366-375.

[13] Cheng C L,Yan L L,Li M L,et al. A Novel Amperometric Biosensor Based on NiO Hollow Nanospheres for Biosensing Glucose[J]. Talanta,2008,7(1):455-459.

[14] ZHANG Guide,LI Xuejin. Optical Waveguide Gas Sensor[J]. Instrum Tech Sens,1990,(5):17-19(in Chinese).

张贵德，李学金. 光波导气体传感器[J]. 仪表技术与传感器，1990,(5):17-19.

[15] ZHANG Rongjun,HUANG Rongjie,ZHAO Jiantao. Moderate Temperature Desulfurization by Zinc Ferrite Prepared with Stearate Precursor[J]. Fuel Chem Technol,2007,35(2):217-221(in Chinese).

张荣俊，黄戒介，赵建涛. 硬脂酸前驱体法制铁酸锌脱硫剂及其在中温下的应用[J]. 燃料化学学报,2007,35(2):217-221.

[16] XU Jiaqiang,HAN Jianjun,SUN Yu′an,et al. The Progress in Sensingmechanism of Semiconductor Gas Sensors[J]. Transducer Microsyst Technol,2006,25(11):5-8(in Chinese).

徐甲强,韩建军,孙雨安,等. 半导体气体传感器敏感机理的研究进展[J]. 传感器与微系统,2006,25(11):5-8.

[17] WANG Ji,BAO Huacheng,YAO Pengjun,et al. Research on Improvement of Sensitivity Characteristics of Doped-SO2 Formaldehyde Gas Sensor[J]. Micronanoelectronic Technol,2007,7(8):332-334(in Chinese).

王兢,包化成,姚朋军,等. 掺杂改善SnO2甲醛气敏元件灵敏度特性的研究[J]. 微纳电子技术,2007,7(8):332-334.

[18] ZHANG Yuying. Semiconductor Optoelectronics[M]. Shanghai:Shanghai Science and Technology Press,1987:23-25(in Chinese).

张雨印. 半导体光电子学[M]. 上海:上海科技出版社,1987:23-25.

[19] Bradshaw J T,Mendes S B,Saavedra S S. Planar Integrated Optical Waveguide Spectroscopy[J]. Anal Chem,2005,77(1)：28A-36A.

[20] CHEN Kai,WU Wenpeng,ZHEN Shunxuan,et al. Study on Ammonia-Sensitive Optical Property of ZnO/TiO2 Multi-Layer thin Film[J]. Laser Technol,2001,6(3):209-213(in Chinese).

陈凯，吴文鹏，郑顺镟，等. ZnO/TiO2多层薄膜氨气敏光学特性研究［J］. 激光技术,2001,6(3):209-213.

Preparation of Nickel Oxide-Zinc Ferrite Composite Thin Film/Tin-diffused Glass Optical Waveguide Sensor and Its Gas-sensing for Hydrogen Sulfide

PDF

Knowledge

Cited

Abstract

Cite this article

share this article

References

Related Articles 2

Recommended Articles

Metrics

Comments

[1]	TURDI Gulmira, TURSUN Arken, TURGUN Amangul, YIMIT Abliz. Zinc Tetraphenylporphyrin Film Optical Waveguide Sensor for Detection of Volatile Organic Compound Gases [J]. Chinese Journal of Applied Chemistry, 2015, 32(2): 232-238.
[2]	Dilbar Ahmat1, Erkin Tursun2, Xawkat Abliz2, Abliz Yimit2*. Fabrication of Composite Optical Waveguides Based on Thin Films Consisted of Iron Phosphate Nanoparticles and Their Applications as Ammonia Gas Sensor [J]. Chinese Journal of Applied Chemistry, 2010, 27(08): 965-969.